Atlantic Airways Flight 670 was a crash following a runway overrun of a British Aerospace 146-200A at 07:32 on 10 October 2006 at Stord Airport, Sørstokken, Norway. The aircraft's spoilers failed to deploy, causing inefficient braking. The Atlantic Airways aircraft fell down the steep cliff at the end of the runway at slow speed and burst into flames, killing four of sixteen people on board.
The flight was chartered by Aker Kværner from Stavanger Airport, Sola via Sørstokken to transport its employees from there and Stord to Molde Airport, Årø. An investigation was carried out by the Accident Investigation Board Norway (AIBN). It was not able to find the underlying cause of the spoiler malfunction. However, it found that, when the captain selected the emergency braking, the anti-lock braking system was disabled. This selection caused the brakes to completely lock, resulting in reverted rubber hydroplaning, a condition in which the tires became extremely hot due to frictional forces, and the water on the damp runway surface evaporated to steam, effectively causing the tires to float on a cushion of steam over the runway surface, greatly reducing braking action. This situation was made worse with a minimal runway end safety area and lack of grooves in the runway surface.Air Crash Investigation 2016 Episode: "Edge of Disaster".
Flight Flight 670 was a regular, chartered morning return flight for Aker Kværner to transport its employees from Stavanger Airport, Sola and Stord Airport, Sørstokken to Molde Airport, Årø on 10 October 2006. The aircraft had landed at Sola at 23:30 the day before and a 48 flying hour scheduled inspection was carried out during the night and completed at 05:00. The flight departed Sola at 07:15, just after schedule, with twelve passengers and a flight crew of four. The pilot in command, 34-year-old Niklas Djurhuus, was pilot flying (PF), while the first officer, 38-year-old Jakob Evald, was pilot monitoring (PM).AIBN: 5 The pilots had flown in as passengers on an Atlantic Airways flight to Stavanger the evening before. The commander had carried out twenty-one landings at Sørstokken previously.AIBN: 13 The weather was reported as wind speed of , a few clouds at altitude, visibility exceeding and air pressure (QNH) of .
Aircraft The aircraft was a British Aerospace 146-200 (BAe 146), serial number E2075, registered OY-CRG, first flown in 1987 and originally sold to Pacific Southwest Airlines, in the United States. Six months later it was sold to Atlantic Airways as the first of this type in its fleet. The last inspection was carried out on 25 September 2006, 2 weeks before the accident. At the time of the accident, the aircraft had flown more than 30,000 hours and about 22,000 cycles.AIBN: 16
The BAe 146 is a jetliner specifically designed for short runway operations. Equipped with four Avco Lycoming ALF502R-5 geared turbofan engines, the aircraft is designed for flat landings, where the main and nose landing gears hit the runway nearly simultaneously. It has powerful wheel-brakes and airbrakes, with large spoilers to dump lift immediately on touchdown, but lacks thrust reversers.AIBN: 15
Airport and airline
Stord Airport, Sørstokken is a municipal, regional airport located on the peninsula of Sørstokken on the island of Stord at an elevation of . The runway, aligned 14/32 (roughly north-north-west and south-south-east) is long and wide. It has thresholds on each end and a landing distance available of .AIBN: 35 At both ends of the runway the ground slopes steeply downwards. This was sufficient safety area according to requirements at the time of the airport's construction, but the requirements had been changed by the time of the accident.AIBN: 36 The runway was presumed to be damp at the time of the accident, although such information was not relayed to the pilots.AIBN: 34
Atlantic Airways is the national airline of the Faroe Islands and was at the time owned by the Government of the Faroe Islands. OY-CRG was one of five BAe 146s in Atlantic Airways' fleet at the time of the accident.AIBN: 63 The airline was flying a long-term charter contract with for Aker Kværner, who was participating in the construction of the gas field Ormen Lange in the vicinity of Molde. The contract involved regular flights between Stavanger Airport, Sola via Stord Airport, Sørstokken to Molde Airport, Årø and return five times each week. The company also flew to Alta Airport from Stavanger and Stord in relation to the construction of Snøhvit. To allow full take-off weight for the latter service, Atlantic Airways applied the Civil Aviation Authority of Norway on 18 February 2005 for permission to use a longer take-off distance at Sørstokken. This was rejected because the airport's limits were already below international minimum recommendations.AIBN: 64
Accident Flight 670 contacted Flesland Approach at 07:23, stating that they would land on runway 15 and that they would carry out a visual approach. Flesland approach cleared the aircraft for a descent to at 07:24. The aircraft left controlled airspace at 07:27, at which time the aerodrome flight information service (AFIS) at Sørstokken had visual sight of the aircraft. The pilots decided to land at runway 32 as it would give a faster approach. The flaps were extended to 33 degrees at 07:31:12, reducing ground speed from .AIBN: 6 The pilots aimed for a ground speed of at touchdown and were guided by the precision approach path indicator. Upon passing the threshold the aircraft had a slightly high speed, at . The aircraft touched down at 07:32:14, a few meters past the ideal landing point, in a soft landing.AIBN: 8
The first officer called for the arming of the spoilers one second after touchdown, and the commander armed them half a second later. Two seconds later the first officer called "no spoilers" as the spoiler indicator light had not switched on. He then verified the hydraulic pressure and that the switch was set correctly. Meanwhile, the commander had switched the thrust levers from flight idle to ground idle, and six seconds after touchdown activated the wheel brakes. From 12.8 seconds after touchdown various screeching sounds could be heard from the tires. The braking took place nominally until halfway down the runway. From this point the pilots reported that nominal retardation did not occur. The commander attempted to use the brake pedals to apply full braking, without effect. He then moved the brake lever from green to yellow and subsequently emergency brake, disconnecting the anti-lock.AIBN: 9 Witnesses observed smoke and spray emitted from the landing gear.AIBN: 10
By then, the aircraft had insufficient speed to abort the landing. Aware that the aircraft most likely would overrun, the commander opted to not steer it off the left where there was a steep descent, or to the right where there were rocks. As a last resort, the commander attempted to reduce speed by skidding the aircraft by first steering it right, and then abruptly to the left. The aircraft overran the runway at 22.8 seconds after touchdown, at 07:32:37. At the same time, the crash alarm was activated by AFIS. The aircraft slid off the runway at about a 45-degree angle, roughly north-west.
Rescue
The AFIS controller activated the emergency alarm at 07:32:40. This was confirmed by the rescue crew four seconds later. Five seconds after that, the AFIS controller called the Emergency Medical Communication Center. The police were then notified four minutes later, as was the Joint Rescue Coordination Centre of Southern Norway, who dispatched air ambulance services. The police arrived at the scene at 07:44.AIBN: 55
The aircraft landed at a site located from the end of the runway and from the sea.AIBN: 47 Once the aircraft had come to a halt, the pilots turned off the fuel supply and activated the engine fire extinguishers. They were not able to order evacuation by intercom, as it was not functioning.AIBN: 58 The forward starboard door could not be opened due to a jam, while the cockpit and forward port door were both blocked. The pilots evacuated through the left cockpit window, while all surviving passengers evacuated through the aft port door. The pilots attempted to open the jammed front port door, but failed. The commander then re-entered the cockpit to again attempt to open the cockpit door, but failed. By then the heat hindered further attempts. Both pilots were seriously injured in the process. The injured were flown to hospital by air ambulance. Several of the passengers sitting close to the front of the aircraft decided to evacuate towards the aft, as that part of the aircraft was more intact.AIBN: 59
After it slid off the runway, parts of the aircraft caught fire. This reached high intensity and centered around the middle section of the fuselage and the right wing.AIBN: 52 The fire was not started when the aircraft left the runway, but commenced no later than 13 seconds afterwards. Forty-five seconds after the overrun the first fire engine arrived at the scene, the second five seconds after that. By 1 minute and 45 seconds after overrun, most of the fuselage was on fire. The tail collapsed at 3 minutes and 30 seconds after the overrun, and at 5 minutes and 45 seconds after the overrun the inside left engine stopped running. One fire engine left to resupply with water at 8 minutes, returning at 13 minutes. The first municipal fire engine came to the scene after 18 minutes.AIBN: 53 The fire crew initially did not see anyone near the wreckage and presumed all the passengers had died. Only later did they realize that people standing nearby were actually survivors.AIBN: 61 The fire was extinguished at 09:30.AIBN: 54
Most of the fuselage was destroyed in the fire. Exceptions included the nose and the underside of the cockpit. The tips of the wings and ailerons were nearly undamaged. The front wing spar was sufficiently intact that it was able to keep the wings together. The inner parts of the wing, including the spoilers, were destroyed, but two of the spoiler actuators were salvageable.AIBN: 48 The tail was largely intact. Most light alloy components in the engines were destroyed, although the compressor blades were intact and showed no sign of damage prior to impact.AISN: 49 Three components – the left main landing gear, an engine cowling and the outer right engine – were found between the runway and the wreckage, and had not been consumed in fire.
Investigation
The investigation was carried out by the Accident Investigation Board Norway (AIBN), who arrived by helicopter at the scene at 13:08.AIBN: 42 Three individuals filmed the accident, of which one was especially useful: from 13 seconds after the aircraft left the runway and subsequent 21 minutes was filmed by a witness across Stokksundet, from the site of impact. He sold the tape to TV 2, which subsequently handed the video over to AIBN. The investigators concluded that the runway was damp when they arrived, but were not able to conclude if it was wet at the time of the accident. It was nearly impossible to carry out a meaningful investigation of the fuselage because of the heat damage, although the detached left landing gear could be investigated.
The commission mapped all skid marks on the runway. The first skid marks found to be by OY-CRG was at past the threshold for runway 32.AIBN: 41 The aircraft also left rubber tire debris. Initially following the centerline, the aircraft was found to drift to the right after and then shifted direction after . From the aircraft was skidding to the left, gradually reaching an angle of twenty-five degrees, at the time it ran off the runway at .AIBN: 46